Ranch Hand Supply is Your East Coast Jinma Dealer & Importer___________

** Dyno Tuned & Tested Tractors **

We believe a good Tractor starts with a Great Pre Delivery Service and Assembly.......

 no matter what makes it.

All factory oils are drained and upgraded to US oils.

Engine oil , 15W40  

Hydraulic Oil,  AW32  

Gear Oil, 80w90 GL5    

Power Steering,  AW32

Injection Pump Oil, 15W40

The Clutch Pedal is inspected and adjusted for proper bearing clearance & clutch pedal travel & PTO operation. Four Adjustments. ( we find all of them out of adjustment).

Brake pedals are inspected and adjusted for proper brake pedal travel & operation.

Brake linings are inspected. 

Hydraulic system is inspected, Pressure Tested and adjusted for proper operation and operator hydraulic adjustments are operational.

Engine cooling system is filled with 50/50 Distilled Water and a Low Silicate Antifreeze.

Fuel Tank, Lines, Bowl and Screens cleaned.

Fuel tank flushed with diesel prior to installation.

Battery Charged, Load Tested and Anti- Corrosion pads installed on Battery Post.

Check differential lock actuator operation.

Check all electrical systems cables and wire routings.

All instruments and gauges operational.  Chassis grounds cleaned.

Steering function and toe in.

Injection timing.

Hand and foot throttle operation.

Drain fuel injection pump housing oil sump and refill 10w40.

Sliding seat track lubed.

Tire Pressure set.

and more.....................

Lubricants

Most all will agree that the Oil Lubricants that come in the tractors from the factory are not as good as U.S. oil lubricants. That is why we replace all the oils.

We recommend that you stay with a good quality oil and keep gear oil in gear boxes, hydraulic oil in the hydraulics, diesel engine oil in a diesel engine etc.

The diesel engine fuel injection pump comes with engine oil in the sump for lubrication and cooling. We recommend that you keep engine oil in the injection pump when you perform your oil service. Use the same oil that you put in the engine. The reason is..... the pump was designed to be lubricated with engine oil. A good quality U.S. diesel oil has all the detergents and additives needed to lubricate and care for the pump.

For the ones that do not know.... a lot of injection pumps on  larger diesel engines do not have a separate oil sump....it is supplied oil from the engine's oil system/pump pressure.  It is not uncommon for farmers & tractor  mechanics to expect to get 5000 hours before they have to go into an engine for repair or rebuild. A lot of attention is paid to engine break-in also so correct lubricants are used and kept on maintenance program. 

Another tid bit,  good clean quality diesel fuel plays a big factor in how long the injectors and pump will last.

We will put the tractor up on jack stands straight out of the crate before we start our PDSA. Other than making it easier to service.....it allows us to inspect, turn, rotate, clean, adjust, service and operate the complete tractor as we assemble. 

Once the tractor is assembled, we will then let the engine idle while it is on jack stands until it reaches operating temperature. We then let it run at different engine RPM'S, while operating the hydraulics, steering, 4X4, shift through all transmission speeds, PTO and inspect for leaks.

All electrical ground connections are cleaned and an anti corrosion paste is applied.

 While performing this test any and all adjustments or repairs are made if found.

Running a tractor on a PTO Dyno really puts the test to a tractor. One could almost look at it as ....... if it lived through the Dyno test , IT'S A GOOD ONE !.

Thank you for considering Ranch Hand Supply. Sign our Guest Book.

Please note that when you receive your new tractor it will not have zero hours on the meter. The clock is ticking while we are performing the final stages of the PDSA and depending on the hours the factory put on the clock .

 We will put at least

 2 hours on hour meter.

We feel that giving your new tractor the opportunity to run, and having all levers, switches and systems exercised and checked, Dyno tested will give you a good tractor from a good dealer that has been professionally assembled and tested .

Thank you for considering

 Ranch Hand Supply